Home>News Center>World

NASA: Discovery looks OK to fly home
Updated: 2005-07-29 08:28

Space shuttle Discovery escaped damage from the potentially deadly chunk of foam that broke off from the fuel tank during liftoff, but may have been struck in the wing by a much smaller piece, NASA said Thursday, reported AP. 

Even if the slight foam fragment did hit, the impact most likely caused no significant damage, said deputy shuttle program manager Wayne Hale.

"We think that that little piece of foam, at that altitude, did not cause any damage of concern," Hale said at an evening press conference.

Despite the latest development, officials said Discovery still looks safe to fly home in a week, but stressed that it will be another few days before the space agency can conclusively give the shuttle a clean bill of health.

In this image from NASA TV Mission Specialist Wendy Lawrence is greeted by Astronaut Sergei Krikalev after the space shuttle Discovery docked with the international space station, Thursday, July 28, 2005. (AP
In this image from NASA TV Mission Specialist Wendy Lawrence is greeted by Astronaut Sergei Krikalev after the space shuttle Discovery docked with the international space station, Thursday, July 28, 2005.[AP]
The mostly welcome news came after Mission Control received stunningly detailed photographs of Discovery taken by the crew aboard the international space station. The shuttle executed an unprecedented backflip to bare its belly to the cameras before docking with the space station.

NASA wanted to make sure Discovery did not suffer the kind of mortal wound that brought down Columbia in 2003.

"The initial report was that it looks extremely good and we don't have anything to worry about on Discovery," flight operations manager John Shannon said earlier in the day.

On Wednesday, NASA suspended all further shuttle flights after learning that a big piece of foam insulation weighing just short of a pound came flying off Discovery's external fuel tank in an alarming repeat of the problem that doomed Columbia. Neither that piece nor most of the other, smaller chunks struck Discovery, officials said.

The one that may have hit Discovery's right wing came off about 20 seconds after the big piece, and was from the same general area, Hale said. None of the wing sensors detected anything unusual there, and a laser-tipped inspection boom also did not pick up any damage. Camera views during liftoff were inconclusive because the foam tumbled out of sight.

NASA already has run tests showing that if the foam did strike the wing, it would have exerted just one-tenth of the energy needed to cause worrisome damage, Hale said.

All that remains before NASA can clear Discovery and its seven astronauts for landing is an inspection, on Friday, by a new laser-tipped boom that will provide 3-D views of scraped thermal tiles on the shuttle's belly. The 100-foot crane will be able to determine the depth of what looks to be surface-coating damage, Shannon said.

If everything checks out as NASA expects, then Discovery will be free to return to Earth on Aug. 7 as planned, following an eight-day space station visit.

Shuttle managers were stunned after seeing video images of the large piece of foam shooting off the fuel tank two minutes after Tuesday's liftoff. It weighed about half as much as the piece that slammed into Columbia's left wing and was irregular in shape, at 24 to 33 inches across.

It was not until Wednesday, after viewing more video and still images from space, that managers knew where the foam came from. The foam broke off an area meant to protect cables and pressurization lines running down the length of the 15-story fuel tank, not even close to the location of Columbia's broken insulation.

Three smaller pieces of foam broke off the same area of Discovery's fuel tank, including a 7-inch-long chunk that missed Discovery, Hale said.

Shuttle managers considered modifying the area after Columbia's catastrophic re-entry on Feb. 1, 2003. But they put it off because they had had little trouble with the foam there in the past, and it was a relatively easy area to check for air pockets that might cause the insulation to pop off during launch.

Shannon said that decision was based on limited flight data. Engineers had no good tank images from more than 50 of the 113 previous shuttle launches; of the remainder, only one liftoff resulted in foam loss from that area and it was attributed to a previous repair.

"As everybody who's come up here in the last two days has said, we were wrong and we missed something and we have to go figure out what it was and go fix it," Shannon said. "Whether that's just changing techniques or redesign, we don't know."

Until the problem is fully understood and resolved, NASA has decreed that no more shuttles will be launched.

The grounding cast a pall over Mission Control and the rest of the space program. Flight director Paul Hill gave his team a pep talk before Discovery started making its final approach to the space station, reminding them, "We have a job to do. We have a crew that is relying on us."

Still ahead are three spacewalks by Discovery's astronauts, supply transfers between the two linked spacecraft, the shuttle's undocking, and its descent back to Earth.

"We don't have the luxury of sitting around and thinking about what does this mean to the program, or what are we going to do after" Discovery's mission, Hill said. He added, "It's all about taking care of Eileen Collins and her crew."

American women call for end of war
Israeli forces storm Gaza settlement
South Korean, DPRK separated families hold video reunions
  Today's Top News     Top World News

Guangzhou oil supply 'returning to normal'



First joint drill with Russia launched



Scotland bank in US$3.1b deal for BOC stake



China-US textile talks make progress



Opinion: Corruption has to stay capital crime



'Bird flu may cause global economic mayhem'


  al-Qaida leader in Saudi Arabia killed
  Iraq lawmakers work on draft constitution
  Israeli forces storm Gaza Synagogues
  Encephalitis kills 79 children in India
  Almost 90 arrested after Bangladesh bombings
  Tigers agree to review Sri Lanka truce, emergency extended
  Go to Another Section  
  Story Tools  
  Related Stories  
Shuttle, space station link amid NASA woes
Discovery docks with Space Station
NASA stops shuttle flights until hazard fixed
NASA studies debris recorded during launch
Shuttle crew begins first full day of work
  News Talk  
  Are the Republicans exploiting the memory of 9/11?